dfawlt Posted March 16, 2013 Share Posted March 16, 2013 I just bought a new bike and its just pissing oil. I want to get a better look and remove the tank. The service manual says turn the fuel cock to on before removing everything. It also says to start the engine and get it warm and doesn't say to turn the engine off. I'm worried about leaking fuel everywhere. Is it simply removing the fuel pipe, vacuum pipe and breather pipe then taking the bolt out and popping the tank off? Do I really leave the fuel cock to ON and disconnect stuff? Link to comment Share on other sites More sharing options...
neversaydie Posted March 16, 2013 Share Posted March 16, 2013 Leave the fuel cock on The cock operates buy using the vacuum created by the engine, the vac pulls the piston in the cock into the open position, allowing the fuel through to the engine. Engine not running, no fuel flow Is it pissing oil, or is it pissing fuel, your statement isnt clear, if one or the other where is it/they leaking from? For tank removal, key in the seat lock and remove the seat, undo and remove the bolt at the back end of the tank, lift the back end of the tank a couple of inches, then pull the tank directly backwards. The front f the tank locates on 2 round rubber bungswhch are fixed to the frame. They may well be tight to pull off, work the tank sideways a little at a time to break any crap holding them in. Be patient. Careful not to pull any of the pipes off the fuel tap Once the tank is free, chock it up a few inches with a piece of wood, make a note of which pipe comes from where/goes to where on the cock, then disconnect them Dontdo it with the engine on If your cock is good, it shouldnt leak, it it is thats your problem, seal kits are available, but many folk over the pond simply replace the cock with a straight on/off/resrve type. If you do that, dont forget to blank off the vac connection on the engine rubber Good luck Link to comment Share on other sites More sharing options...
dt502001 Posted March 17, 2013 Share Posted March 17, 2013 Contact your local bike dealer do not atempt this yourself ! Link to comment Share on other sites More sharing options...
Sacha Posted March 19, 2013 Share Posted March 19, 2013 ...If your cock is good, it shouldnt leak... If your cock is leaking, you should see the doctor... (Couldn't resist...sorry) Link to comment Share on other sites More sharing options...
neversaydie Posted March 19, 2013 Share Posted March 19, 2013 I left it wide open, my money was on Up Yours You gals 1 Link to comment Share on other sites More sharing options...
Recommended Posts